2020 BMW Z4 recalls

6 safety recalls, 5 owner complaints. Official NHTSA data.

2025202220202019
6Recalls
5Complaints
1Crashes & fires reported
N/ANHTSA overall rating

Not every 2020 BMW Z4 is affected by every recall. Check your VIN to see open recalls on your exact vehicle.

Check my VIN

2020 BMW Z4 recall list

Electrical System recall

Park outside25V-636
September 23, 2025 · BMW of North America, LLC
Problem
BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
Safety risk
A short circuit in the starter relay may increase the risk of a fire.
Remedy
Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 14, 2025.

Engine recall

21V-598
August 2, 2021 · BMW of North America, LLC
Problem
BMW of North America, LLC (BMW) is recalling certain 2020 M340i, M340i xDrive, 540i, 540i xDrive, X3 M40i, 2020-2021 X4 M40i, 745Le xDrive, 2019-2021 Z4 M40i, and 2020-2021 Toyota Supra vehicles. During engine start, the engine management software may cause loss of braking assist. Full mechanical braking (without assist) remains available.
Safety risk
Loss of braking assist can increase the risk of a crash.
Remedy
Dealers will update the engine management software, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact BMW customer service at 1-800-525-7417.

Fuel System, Gasoline recall

20V-700
November 12, 2020 · BMW of North America, LLC
Problem
BMW of North America, LLC (BMW) is recalling certain 2020-2021 Z4 and 2020-2021 Toyota Supra vehicles. The weld between the fuel tank halves may have been insufficiently welded, causing the weld to fail.
Safety risk
The failed weld may allow fuel to leak, increasing the risk of a fire in the presence of an ignition source.
Remedy
BMW will notify owners, and dealers will replace the fuel tank, free of charge. The recall began December 18, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.

Exterior Lighting recall

20V-516
August 27, 2020 · BMW of North America, LLC
Problem
BMW of North America, LLC (BMW) is recalling certain 2019-2020 Z4 sDrive30i, Z4 M40i and 2020 Toyota Supra vehicles. The headlamps are able to be adjusted horizontally. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices and Associated Equipment."
Safety risk
Should the headlamps be adjusted horizontally, there could be increased glare and reduced visibility for oncoming drivers, or reduced visibility for the vehicle operator, thereby increasing the risk of a crash.
Remedy
BMW will notify owners, and dealers will inspect the headlamp vertical and horizontal adjustment plugs, correcting them as necessary, free of charge. The recall began December 23, 2020. BMW owners may contact BMW customer service at 1-800-525-7417 or Toyota owners may contact Toyota customer service at 1-888-270-9371.

Exterior Lighting recall

19V-850
November 27, 2019 · BMW of North America, LLC
Problem
BMW of North America, LLC (BMW) is recalling certain 2020 Z4 M40i, Z4 sDrive30i, 330i and 330i xDrive vehicles as well as 2020 Toyota Supra vehicles. The headlight control units may fail causing a loss of one or both of the headlights.
Safety risk
Headlight failure can reduce the driver's visibility, increasing the risk of a crash.
Remedy
BMW will notify owners, and dealers will replace the headlight control units, free of charge. The recall is expected to begin January 17, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.

Back Over Prevention recall

19V-684
September 28, 2019 · BMW of North America, LLC
Problem
BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Safety risk
The lack of an image in the back-up camera display increases the risk of a crash.
Remedy
BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.

2020 BMW Z4 owner complaints

5 complaints filed with NHTSA, including 1 crash, 0 fires, 0 injuries and 0 deaths.

Problems by component

Electrical System2
Engine2
Steering2
Service Brakes2
Unknown or Other1
Suspension1
Structure1

Recent complaints

July 21, 2026Electrical SystemUnknown or OtherEngine

The engine starter failed on my 2020 BMW Z4 M40i. The vehicle experienced starting failures and the repair shop diagnosed a faulty/shorted engine starter assembly. The symptoms and component failure match the exact defect description of active safety recalls NHTSA 24V-576 and 25V-636 (Starter Motor Fire Risk due to electrical short circuit/overheating). However, when checking my specific 17-digit VIN, the manufacturer has excluded my vehicle from the recall population. Because this is an identical component failure that poses a severe vehicle fire and safety hazard, I am requesting that the NHTSA investigate a recall expansion to include my vehicle's production batch. I have retained the dia

February 19, 2026Electrical System

Engine starter safety recall came out in September 2025, with no remedy or parts existing for fixing it. 5 months later, and no timeframe is provided for a remedy. This is a major fire risk given the amount of rain now that could corrode the starter and lead to a fire.

November 26, 2020SteeringSuspensionService Brakes

DON'T KNOW WHAT IS CAUSING IT. THERE IS MAJOR SQUEAKING/WHINING/GRINDING NOISE IF EVEN A TINY BIT OF WATER GETS IN THERE AND LAST COUPLE DAYS AFTER THAT. AND WHEN YOU TURN THE STEERING WHEEL TO THE LEFT THE SQUEAKING/WHINING GETS LOUDER. AND WHEN DOES DO THIS THE SUSPENSION IF YOU HIT EVEN A SMALL BUMP WILL BOTTOM OUT AND MAKE GRINDING NOISES. BMW HAS LOOKED AT THE CAR COUPLE TIMES FIRST TIME THEY SAID THERE WAS RUST. SECOND TIME THEY COULDN'T FIND ANYTHING WRONG WITH IT.

October 7, 2020StructureService BrakesEngineCrash

WAS IN A DRIVE THRU ON 9/6/2020 WAITING OUR TURN. APPROX. 7 CARS IN FRONT OF US. AS WE ARE SLOWLY MOVING UP TO ORDER, CAR IN IDLE, FOOT ON BRAKE. AS WE ARE MOVING FORWARD, WHEN WE WERE UP TO 3 CARS, STILL IDLING AND FOOT ON BRAKE, THE CAR HAD FULLY ACCELERATED, BRAKE NOT HOLDING THE CAR, INCHING FORWARD DUE TO THE FORCE OF THE ACCELERATION. TRIED TO SHIFT INTO NEUTRAL, WENT INTO REVERSE. TRIED AGAIN TO SHIFT INTO NEUTRAL, WENT INTO DRIVE, STILL INCHING FORWARD, AT THIS TIME I PUSHED THE OFF BUTTON TO STOP THE CAR. RESULT OF COLLISION WITH THE VEHICLE IN FRONT OF US. WE HAVE PHOTOS BUT NOT ON THIS COMPUTER.

December 14, 2019Steering

BMW'S LANE DEPARTURE SYSTEM ACTUALLY PULLS THE CAR'S STEERING LEFT OR RIGHT, AND COULD CAUSE THE CAR TO COLLIDE WITH ANOTHER VEHICLE OR RUN OFF THE ROAD. I EXPERIENCED THIS WHILE DRIVING ON THE FREEWAY IN SOUTHERN CALIFORNIA. THE LANE DEPARTURE SYSTEM ALMOST PULLED MY VEHICLE INTO THE ADJACENT LANE.

2020 BMW Z4 crash test ratings

VersionOverallFrontalSideRollover
2020 BMW Z4 C RWDNot ratedNot ratedNot ratedNot rated

Driver aids on the tested 2020 BMW Z4: electronic stability control standard, forward collision warning no, lane departure warning no.

2020 BMW Z4 recall FAQ

Does the 2020 BMW Z4 have any recalls?

Yes. NHTSA lists 6 safety recalls for the 2020 BMW Z4. The most recent, filed September 23, 2025, concerns the electrical system.

What are the most common 2020 BMW Z4 problems?

Owners have filed 5 complaints with NHTSA. The most reported area is electrical system (2 reports), followed by engine.

Is the 2020 BMW Z4 safe?

NHTSA has not published an overall crash test rating for the 2020 BMW Z4.

How do I get a recall fixed on my 2020 BMW Z4?

Contact any authorized BMW dealer. Recall repairs are free, even if you are not the original owner or the warranty has expired.