2019 Chevrolet 6500 recalls

1 safety recall, 1 owner complaint. Official NHTSA data.

2019
1Recalls
1Complaints
1Crashes & fires reported
N/ANHTSA overall rating

Not every 2019 Chevrolet 6500 is affected by every recall. Check your VIN to see open recalls on your exact vehicle.

Check my VIN

2019 Chevrolet 6500 recall list

Service Brakes, Hydraulic recall

Park outside25V-390
June 12, 2025 · General Motors, LLC
Problem
General Motors (GM) is recalling certain 2019-2024 Chevrolet Silverado Medium Duty 4500HD, 5500HD, and 6500HD vehicles. The brake pressure sensor assembly may leak brake fluid into the brake pressure switch and cause a short circuit.
Safety risk
An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.
Remedy
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch wire harness, free of charge. Owner notification letters were mailed September 11, 2025. Owners may contact GM customer assistance number at 1-866-467-9700. GM's number for this recall is N242482680. Vehicles in this recall that were previously repaired under 23V266 will need to have the new remedy completed.

2019 Chevrolet 6500 owner complaints

1 complaint filed with NHTSA, including 0 crashes, 1 fire, 0 injuries and 0 deaths.

Problems by component

Electrical System1
Service Brakes1

Recent complaints

October 2, 2024Electrical SystemService BrakesFire

The brake switch nearly burned the truck to the ground could smell the electrical burning, and the brake pressure failed due to a brake line failure Chevrolet says, the switch was covered in recall. But the say the brake lines arent covered. These same brake lines were recalled on Chevrolet commercial van chassis. This could have resulted in serious injury or death if it hadn't have failed at very low speeds. This is urgent an needs to be addressed. This vehicle has been in arkansas, not up north with salt on the roads. The brake lines shouldn't fail on a truck that's less than 4 years old.

2019 Chevrolet 6500 recall FAQ

Does the 2019 Chevrolet 6500 have any recalls?

Yes. NHTSA lists 1 safety recall for the 2019 Chevrolet 6500. The most recent, filed June 12, 2025, concerns the service brakes, hydraulic.

What are the most common 2019 Chevrolet 6500 problems?

Owners have filed 1 complaint with NHTSA. The most reported area is electrical system (1 reports), followed by service brakes.

Is the 2019 Chevrolet 6500 safe?

NHTSA has not published an overall crash test rating for the 2019 Chevrolet 6500.

How do I get a recall fixed on my 2019 Chevrolet 6500?

Contact any authorized Chevrolet dealer. Recall repairs are free, even if you are not the original owner or the warranty has expired.