NHTSA recall 23V-625: Power Train

Ford Motor Company · Reported September 8, 2023 · 3 affected model years

Power Train recall

23V-625
September 8, 2023 · Ford Motor Company
Problem
Ford Motor Company (Ford) is recalling certain 2024-2025 Ford E-350, F-650, and F-750 vehicles. The park pawl may not fully engage the park gear due to a casting defect in the transmission.
Safety risk
A vehicle which does not have the park pawl fully engaged may result in a vehicle rollaway, increasing the risk of a crash.
Remedy
Dealers will inspect and replace the transmission, or the valve body and extension housing, as necessary, free of charge. Owner notification letters were mailed January 16, 2024. Owners may contact Ford's customer service at 1-866-436-7332. Ford Motor Company's number for this recall is 23S54.

Recall details

NHTSA campaign number23V625000
ManufacturerFord Motor Company
Report dateSeptember 8, 2023
ComponentPower Train:Automatic Transmission:Internal:Park Pawl
Fixed over the airNo

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

View on NHTSA.gov ↗

Affected vehicles

2025 Ford E-3501 recall total2025 Ford F-6503 recalls total2024 Ford E-3501 recall total

Related power train recalls

Power Train recall

26V-576
September 9, 2026 · Ford Motor Company · 2026 Ford F-150

Ford Motor Company (Ford) is recalling certain 2026 F-150 vehicles. Incorrect rear axle tail bearings may have been installed, which can result in rear wheel lock-up or driveshaft separation.

Power Train recall

26V-371
June 9, 2026 · Ford Motor Company · 2024 Ford Explorer

Ford Motor Company (Ford) is recalling certain 2024 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.

Power Train recall

26V-301
May 13, 2026 · Ford Motor Company · 2026 Ford Escape

Ford Motor Company (Ford) is recalling certain 2026 Escape and Lincoln Corsair vehicles. The integrated park module may fail to lock into the park position when the driver shifts into park. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."

Power Train recall

26V-236
April 14, 2026 · Ford Motor Company · 2024 Ford Bronco, 2023 Ford Bronco

Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.

All power train recalls →