Power Train recalls

Ford Motor Company (Ford) is recalling certain 2026 F-150 vehicles. Incorrect rear axle tail bearings may have been installed, which can result in rear wheel lock-up or driveshaft separation.

BMW of North America, LLC (BMW) is recalling certain 2020-2026 840i, 840i xDrive, 2021-2023 540i, 540i xDrive, M550i xDrive, and 2024-2026 750e xDrive vehicles. The connection between the driveshaft and the rear differential may become damaged, possibly resulting in a loss of power to the rear wheels or a vehicle rollaway.

Nissan North America, Inc. (Nissan) is recalling certain 2026 Rogue vehicles. The instrument panel may not display the transmission gear selection indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."

Chrysler (FCA US, LLC) is recalling certain 2022-2024 Jeep Grand Cherokee, 2023 Jeep Wagoneer, 2024 Jeep Grand Cherokee L, and Jeep Wagoneer L vehicles. A software error may cause the transmission gear selection indicator not to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission shift lever sequence, starter interlock, and transmission braking effect."

Nissan North America, Inc. (Nissan) is recalling certain 2025 Nissan Sentra vehicles. The front left-side driveshaft may not be fully seated in the continuously variable transmission (CVT) assembly, which can cause a transmission fluid leak and loss of drive power.

Ford Motor Company (Ford) is recalling certain 2024 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.

Ford Motor Company (Ford) is recalling certain 2026 Escape and Lincoln Corsair vehicles. The integrated park module may fail to lock into the park position when the driver shifts into park. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."

General Motors, LLC (GM) is recalling certain 2026 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, and GMC Sierra 1500, Yukon, and Yukon XL vehicles with four-wheel (4WD) or all-wheel drive (AWD), and certain 2015-2020 Suburban, Escalade, Escalade ESV, Yukon, Yukon XL, and Tahoe vehicles. A component missing from the drivetrain transfer case may cause the front and/or rear wheels to lock up without warning to the driver.

Chrysler (FCA US LLC) is recalling certain 2019-2023 Jeep Cherokee vehicles. The power transfer unit (PTU) may fail.

Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.

BMW of North America, LLC (BMW) is recalling certain 2017-2025 K 1600 GT, GTL, B and 2018-2025 Grand America vehicles. The seal for the reverse gear control unit may deteriorate and allow moisture inside the control unit, which can result in the unit overheating.

Lucid USA, Inc. (Lucid) is recalling certain 2024-2026 Air vehicles equipped with Pure Rear-Wheel Drive. Improperly secured bolts may allow the half-shaft to disconnect from the drive unit.

Ford Motor Company (Ford) is recalling certain 2026-2025 F-250 SD and F-350 SD vehicles. The driveshaft friction weld may fail, resulting in rear driveshaft separation and a sudden loss of drive power.

Ford Motor Company (Ford) is recalling certain 2026 Super Duty F-250 and F-350 vehicles. The right rear axle shaft may have been improperly heat-treated during manufacturing and may break.

Ford Motor Company (Ford) is recalling certain 2022-2026 F-150 Lightning BEV, 2024-2026 Mustang Mach-E, and 2025-2026 Maverick vehicles. The integrated park module may fail to lock into the park position when the driver shifts into park. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."

Honda (American Honda Motor Co.) is recalling certain 2025 CB1000SP Hornet SP motorcycles. The pivot bolt on the gearshift pedal may loosen and detach, resulting in the inability to shift gears. As such, these motorcycles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 123, "Motorcycle Controls and Displays."

Jaguar Land Rover North America, LLC (Land Rover) is recalling certain 2025 Range Rover, Range Rover Sport, Discovery Sport, and 2026 Range Rover Evoque, and Jaguar F-Pace vehicles. Moisture may have entered the gear shift module (GSM) during assembly, which can cause the gear shift position indicator light to fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."

BMW of North America, LLC (BMW) is recalling certain 2026 R 1300 RT motorcycles. The cardan shaft may not have been sufficiently hardened, causing the universal joint to slip within the shaft and result in a loss of drive power.

Lucid USA, Inc. (Lucid) is recalling certain 2024-2026 Air vehicles equipped with Pure Rear-Wheel Drive. Improperly secured bolts may allow the half-shaft to disconnect from the drive unit.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2025 Tacoma and Tacoma Hybrid vehicles. The front driveshaft constant-velocity (CV) joint may deform and break.

Chrysler (FCA US, LLC) is recalling certain 2024-2025 Dodge Charger and Jeep Wagoneer S electric vehicles. An incorrectly installed spring may cause the loss of the park function when the vehicle’s gear selector is placed in the park (P) position, which can result in a vehicle rollaway. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."

Ford Motor Company (Ford) is recalling certain 2023-2025 F-150 vehicles equipped with the Trailer Tow Max Duty package and a 9.75-inch heavy duty axle with a 3/4 float axle design. The rear axle hub bolt may fatigue and break, which can result in damage to the axle hub splines.

Chrysler (FCA US, LLC) is recalling certain Ram 2500 and Ram 3500 vehicles equipped with a 3.5" cluster and column shifter. A software error may cause the gear selection display to be inaccurate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."

Hyundai Motor America (Hyundai) is recalling certain 2025 Hyundai Palisade vehicles. An insufficient seal on the controller for the electric oil pump may allow moisture to accumulate in the printed circuit board, which can cause an electrical short and result in a fire.

Ford Motor Company (Ford) is recalling certain 2025 Explorer vehicles. The powertrain control module (PCM) may reset while driving, which can damage the park system or cause an engine stall.

Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Bronco, 2024 Ranger, 2025 Mustang, Explorer, and Aviator vehicles. The transmission valve body may have been machined incorrectly, which can cause reverse gear failure, or unexpected forward movement in reverse or neutral gear.

Ford Motor Company (Ford) is recalling certain 2025 Super Duty F-250, F-350, and F-450 vehicles. The steering column shifter may have been improperly welded and detach from the steering column.

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2022 Escape, and 2021-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 24V-330. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.

Honda (American Honda Motor Co.) is recalling certain 2024 CB650R and CBR650R motorcycles. The fasteners of the gear shift arm may loosen and detach, resulting in the inability to shift gears.

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2025 Atlas and Atlas Cross Sport vehicles. The transmission may have been manufactured incorrectly, which can result in a loss of drive power.

Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2025 E 350, E 350 4MATIC, E 450 4MATIC, and E450 4MATIC station wagon vehicles. The camber strut bracket may have been improperly welded onto the rear axle carrier, possibly resulting in separation of the bracket from the rear axle carrier.

General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Express and GMC Savana vehicles. Incorrect software in the transmission control module (TCM) may result in harsh shifting, reduced power, unintended deceleration, rear wheel lockup, or cause the vehicle to move in an unintended direction.

Mazda North American Operations (Mazda) is recalling certain 2024 CX-90 and 2025 CX-70 vehicles. The powertrain control module (PCM) and engine control modules (ECM) software may cause malfunction indicator lights to illuminate and a loss of drive power.

Ford Motor Company (Ford) is recalling certain 2023-2024 Ford Transit vehicles previously repaired under recall number 24V-102. Incorrect bolts may have been used to attach the rear axle shaft, which can lead to the rear wheel locking up or separating from the axle.

Ford Motor Company (Ford) is recalling certain 2024 Bronco Sport vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

Hyundai Motor America (Hyundai) is recalling certain 2024 Santa Fe vehicles. A software error in the transmission control unit may result in a vehicle roll away when the vehicle is in PARK.

Chrysler (FCA US, LLC) is recalling certain 2023 Ram 1500, 2500, and 3500 vehicles. An insufficient weld in the transmission control unit can allow transmission fluid to leak on to electrical components, resulting in a loss of drive power or loss of park function.

Ford Motor Company (Ford) is recalling certain 2024 Mustang vehicles. The clutch pressure line may be improperly secured and contact hot exhaust components, which can result in melting of the clutch pressure line and cause a brake fluid leak.

Jaguar Land Rover North America, LLC (Land Rover) is recalling certain 2024 Range Rover and Range Rover Sport vehicles. The transmission oil pressure may decrease and cause the clutch to shift into neutral gear, which can result in a loss of drive power.

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.

Nissan North America, Inc. (Nissan) is recalling certain 2024 Sentra vehicles. The front left-side driveshaft may not be fully seated in the continuously variable transmission (CVT) assembly, or may have a loose or missing retaining clip, which can cause a transmission fluid leak and loss of drive power.

Hyundai Motor America (Hyundai) is recalling certain 2024 IONIQ 6 vehicles. The differential gear bolts in the gear drive unit may not be tightened properly, which can result in a loss of drive power or cause the differential to lock up.

Kia America, Inc. (Kia) is recalling certain 2023 Niro EV and 2024 EV9 vehicles. The differential gear bolts in the gear drive unit may not be tightened properly, which can result in a loss of drive power or cause the differential to lock up.

Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The intermediate shaft and right front driveshaft may not be fully engaged, which can result in vehicle roll away while in PARK.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2024 Tundra, Tundra Hybrid, Lexus LX600, and 2023-2024 Sequoia Hybrid vehicles. Unexpected vehicle movement may occur when the vehicle is in neutral and the brakes are not applied.

Ford Motor Company (Ford) is recalling certain 2023-2024 Ford Transit vehicles. An inadequate amount of rear axle lubricant may cause rear axle tail bearing damage and seizure, which can result in wheel lock-up or driveshaft separation.

Hyundai Motor America (Hyundai) is recalling certain 2023 IONIQ 5, IONIQ 6, and Genesis GV60 vehicles. The rear inner driveshaft may have been improperly heat-treated, allowing it to break under load and resulting in a loss of drive power.

Kia America, Inc. (Kia) is recalling certain 2023-2024 Niro EV and 2023 EV6 vehicles. One of the drive shafts may have been improperly heat-treated, allowing it to break under load and resulting in a loss of drive power.