NHTSA recall 25V-158: Power Train

Ford Motor Company · Reported March 14, 2025 · 3 affected model years

Power Train recall

25V-158
March 14, 2025 · Ford Motor Company
Problem
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Safety risk
An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy
Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.

Recall details

NHTSA campaign number25V158000
ManufacturerFord Motor Company
Report dateMarch 14, 2025
ComponentPower Train:Automatic Transmission:Control Module (TCM/PCM/Tecm)
Fixed over the airNo

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.

View on NHTSA.gov ↗

Affected vehicles

2024 Ford Bronco Sport8 recalls total2023 Ford Bronco Sport14 recalls total2023 Ford Maverick21 recalls total

Related power train recalls

Power Train recall

26V-576
September 9, 2026 · Ford Motor Company · 2026 Ford F-150

Ford Motor Company (Ford) is recalling certain 2026 F-150 vehicles. Incorrect rear axle tail bearings may have been installed, which can result in rear wheel lock-up or driveshaft separation.

Power Train recall

26V-371
June 9, 2026 · Ford Motor Company · 2024 Ford Explorer

Ford Motor Company (Ford) is recalling certain 2024 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.

Power Train recall

26V-301
May 13, 2026 · Ford Motor Company · 2026 Ford Escape

Ford Motor Company (Ford) is recalling certain 2026 Escape and Lincoln Corsair vehicles. The integrated park module may fail to lock into the park position when the driver shifts into park. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."

Power Train recall

26V-236
April 14, 2026 · Ford Motor Company · 2024 Ford Bronco, 2023 Ford Bronco

Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.

All power train recalls →