2024 Mercedes-Benz Sprinter 3500XD Crew recalls

The contact owns a 2024 Mercedes-Benz Sprinter 3500 equipped with Kumho Tires, Tire Line: Crugen Premium, Tire Size: 215/85/R16, DOT Number: 1H23PLDV9. The contact stated that while driving 65 MPH with his wife and dog inside the vehicle, the contact heard an abnormally loud sound coming from the front passenger’s side wheel. The contact slowed down and parked the RV at a local gas station. A dealer was not contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The tire was replaced. The manufacturer was notified of the failure and was examining it. The failure mileage was approximately 5,000.

We purchased a new 2025 Jayco Melbourne and afterwards discovered the MBZ 3500 Chassis was a 2024.(6/19/2024) A 2025 MBZ 3500 chassis has a TPMS -factory installed system; 2024 no TPMS. I started to install an aftermarket TPMS and noted the tire valve stems were rubber. I couldn’t install the end cap sensors due to safety concerns about centrifugal force causing a failure of the rubber valve stems on the wheels. My next contact was MBZ customer service. They referred me to Walter’s Mercedes-Benz Van Center, 7979 Auto Drive, Riverside, Ca. 82504. I contacted Service Advisor Brennan Ruiz at 951-552-2145. After a couple of phone calls back and forth and me researching the parts through MBZ, I m

Tried to drive over Wolf Creek Pass in Colorado. About halfway up, the vehicle started losing power and eventually lost all power. The engine was running but even with the pedal to the floor it was totally unresponsive. This put us in a dangerous situation as I had to park on the side of the road with huge drop offs and semi trucks. I managed to turn it around to come down the pass coasting. The engine finally became responsive again at lower altitude. The yellow “check engine” icon was on when this started. Managed to come back to Pagosa Springs and shut it down several times and re started. The engine light finally went off.