2020 Toyota Avalon recalls

3 safety recalls, 10 owner complaints and a 5-star NHTSA crash rating. Official NHTSA data.

202220212020
3Recalls
10Complaints
1Crashes & fires reported
5/5NHTSA overall rating

Not every 2020 Toyota Avalon is affected by every recall. Check your VIN to see open recalls on your exact vehicle.

Check my VIN

2020 Toyota Avalon recall list

Air Bags recall

23V-865
December 20, 2023 · Toyota Motor Engineering & Manufacturing
Problem
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Avalon, Avalon Hybrid, Corolla, Highlander, Highlander Hybrid, RAV4, RAV4 Hybrid, Lexus ES350, Lexus RX350, Lexus RX450H, 2021 Sienna Hybrid, Lexus ES250, 2020-2022 Camry, Camry Hybrid, and ES300H vehicles. A short circuit may develop in the Occupant Classification System (OCS) sensor, preventing the front passenger air bag from deploying.
Safety risk
An air bag that does not deploy during a crash increases the risk of injury.
Remedy
Dealers will inspect and replace the sensor as necessary, free of charge. Interim letters notifying owners of the safety risk were mailed in February 2024. Some final remedy owner letters were mailed October 31, 2024. Letters will continue to be mailed in phases through January 2026. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 23TB15/23TA15 Lexus 23LB03/23LA03.

Air Bags recall

20V-734
November 25, 2020 · Toyota Motor Engineering & Manufacturing
Problem
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Toyota Avalon and 2020 Avalon Hybrid, RAV4, and RAV4 Hybrid vehicles. Breakaway pins within the steering column, designed to absorb energy and reduce injury during a crash, could have been damaged during production, possibly affecting the performance of the driver's air bag in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Safety risk
In the event of a crash, an air bag that does not perform as designed can increase the risk of injury.
Remedy
Toyota will notify owners, and dealers will replace the steering column, free of charge. The recall began December 18, 2020. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 20TB17/20TA17.

Fuel System, Gasoline recall

20V-682
November 4, 2020 · Toyota Motor Engineering & Manufacturing
Problem
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Safety risk
If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy
Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.

2020 Toyota Avalon owner complaints

10 complaints filed with NHTSA, including 1 crash, 0 fires, 0 injuries and 1 death.

Problems by component

Fuel/Propulsion System5
Forward Collision Avoidance2
Air Bags1
Steering1
Vehicle Speed Control1
Service Brakes1
Visibility1

Recent complaints

December 8, 2025Fuel/Propulsion System

A couple of months ago, my car started running a little rough as it would sit in idle mode. When suddenly my check engine light came on. I checked the codes and they seemed to be P0445 Evaporitive emission system leak detected (large leak). And P0441 Evaporative emission system. Incorrect Purge Flow. P0505 Idle control system. And P0171 System to Lean Bank 1 and P0174 System to Lean. Bank 2 and P0172 System Too Rich and P1170 and P117B Manufacture Control. But other then just running a little rough at idle that was about all that I had noticed until I went to go fuel up back in October. My fuel was low so I went to fuel up and after wards, my car struggled really hard to start. And every tim

November 18, 2024Air Bags

To Whom It May Concern, I am filing this complaint to report Right Toyota in Scottsdale, Arizona, and Toyota Motor Corporation for their mishandling of a critical airbag safety recall (23TA15) on my 2020 Toyota Avalon Hybrid. The lack of transparency, misleading information, and failure to provide a remedy has left me with a vehicle that is unsafe to drive and has caused significant financial hardship. 1. Right Toyota never informed me of the recall, despite multiple service visits throughout the year. I only discovered this issue through my insurance company in August 2024. 2. I scheduled service appointments with Right Toyota on August 23rd and October 15th, 2023, after learning about the

July 15, 2024Steering

TIE ROD LOOSE I heard a clunking noise while turning the steering wheel to the left at very low speeds. Took car in for service Service Mechanic found left outer tie rod end "with play, loose" Safety issue: potential loss of steering ability while driving Vehicle has been inspected and repaired - (my cost $1308.94) - images attached No warning messages / appeared about a month before I went in... it became progressively worse with time

November 25, 2023Fuel/Propulsion System

When refueling vehicle, gasoline backs up immediately, doesn't shut off gas hose and pours out all over vehicle and feet of person refueling. Today is the 4th time it's happened. It's been to Gettle Toyota of Lakewood in Bradenton FL for this exact complaint and was told there's nothing wrong with the vehicle.

July 31, 2022Vehicle Speed ControlForward Collision Avoidance

on 3 lane expressway (US422)about 1/4 mile from where the lanes split( see attached). No cars in front of me but cars in the lane to my left slowed. My car suddenly braked causing the car behind me to swerve to my right to avoid a collision. The adaptive breaking (incorrectly) determined that there was a collision hazard, thus creating an actual collision hazard

2020 Toyota Avalon crash test ratings

VersionOverallFrontalSideRollover
2020 Toyota AVALON 4 DR FWD★★★★★★★★★★★★★★★★★★★★

Driver aids on the tested 2020 Toyota Avalon: electronic stability control standard, forward collision warning standard, lane departure warning standard. Rollover risk: 10.5%.

2020 Toyota Avalon recall FAQ

Does the 2020 Toyota Avalon have any recalls?

Yes. NHTSA lists 3 safety recalls for the 2020 Toyota Avalon. The most recent, filed December 20, 2023, concerns the air bags.

What are the most common 2020 Toyota Avalon problems?

Owners have filed 10 complaints with NHTSA. The most reported area is fuel/propulsion system (5 reports), followed by forward collision avoidance.

Is the 2020 Toyota Avalon safe?

The 2020 Toyota Avalon earned up to a 5-star overall safety rating in NHTSA’s New Car Assessment Program crash tests.

How do I get a recall fixed on my 2020 Toyota Avalon?

Contact any authorized Toyota dealer. Recall repairs are free, even if you are not the original owner or the warranty has expired.