2026 Volvo EX90 recalls

While driving my nearly new 2026 Volvo EX90 at freeway speed, the vehicle unexpectedly began sounding warning tones and experienced a significant loss of propulsion/power. The vehicle was unable to maintain normal acceleration and freeway performance, creating a serious safety risk while I was traveling in active freeway traffic. Earlier that day, the vehicle had displayed a warning stating “Charging system fault — book a service.” The vehicle’s GPS/location system was also malfunctioning. The GPS issue had occurred previously. Because of the unexpected loss of propulsion at freeway speed, I no longer considered the vehicle safe to drive. The vehicle was subsequently transported by flatbed t

I purchased a brand-new 2026 Volvo EX90 just 4days ago from a volvo dealership . Yesterday, the vehicle’s software proximity logic malfunctioned and auto-locked the doors while my baby was strapped inside. My physical key card and my phone with the digital key were both inside the cabin. To make matters worse, when I tried to use the Volvo remote app to unlock it with a different phone, the app failed completely because the car was not “connected”. Volvo roadside assistance could not unlock the vehicle either. Because of this total software failure, I had no choice but to have firefighters physically break into my brand-new car to rescue my child."

While driving the vehicle at a low rate of speed it presenter a Critical Error message which appeared across the drivers screen for approximately 5-10 seconds. The message then immediately disappeared and the vehicle shut down mid operation and came to an abrupt stop on its own. From there it was unable to be moved, switched into neutral/drive or park. Luckily this happened on a neighborhood street, but the warning didn’t allow any time to pull over to find a safe location. To reiterate, the vehicle then suddenly and abruptly came to a complete stop mid operation on its own. If this would have happened on the highway or a busy street, it could have been a life threatening event.

Software updates causing mechanical issues. Most recent software update blew the compressor and pump causing the AC to go out. According to volvo service department this is a widespread issue with their software updates for the EX90, who knows what other mechanical issues it may be causing. Safety issue as its 115 degrees outside and car only blows hot air.

Overall, we've been very happy with the EX90, but it's clear the vehicle is in desperate need of a comprehensive software update from Volvo. The issues we're experiencing don't appear to be hardware failures so much as recurring software-related problems. We've received intermittent propulsion system warnings, headlight system warnings, delayed accelerator response at times, and general electrical system sluggishness. The infotainment system can be slow to respond, and various vehicle functions occasionally lag or behave inconsistently before returning to normal. While none of these issues have left the vehicle undrivable, the frequency of the warnings and the overall lack of responsiveness